寶武重慶鋼鐵股份有限公司重鋼煉鐵廠新建3臺260t/h（1#、2#、3#）超高溫亞臨界燃氣鍋爐，配套3臺80MW超高溫亞臨界參數汽輪機等設備，同步配套建設的燃氣鍋爐煙氣脫硫脫硝達標排放凈化系統（簡稱“燃氣項目”）；同時為1#-4#焦?fàn)t新增2套煙道廢氣脫硫脫硝裝置（1#-2#焦?fàn)t對應的為1號機、3#-4#焦?fàn)t對應的為2號機），以實現煙氣超低排放要求。（簡稱“焦?fàn)t項目”）華星東方子公司安徽中易環保為上述二項目提供了核心裝備。
Three 260 t/h (No. 1, 2, 3) ultra-high temperature subcritical gas-fired boilers are newly built in Chongqing Iron and Steel plant of BAOWU Group. The plant equipped with 3 sets of 80 MW ultra-high temperature subcritical steam turbine, flue gas desulfurization and denitrification system for the gas-fired boilers is built accordingly, hereinafter referred to as “gas project”. Meanwhile, 2 sets of flue gas desulfurization and denitrification equipment are added for unit 1 - 4 coke oven (1 & 2 coke ovens for turbine No. 1, 3 & 4 coke ovens for turbine No. 2) to meet the requirements of ultra-low emission standard, hereinafter referred to as “coke oven project".Anhui Zhongyi environmental protection, a subsidiary of Huaxing East, provided core equipment for the above two projects.
“燃氣項目”為重鋼新建富余煤氣高效利用發電項目脫硫脫硝標段脫硫劑制備，供應系統及工藝水系統，其采用與焦?fàn)t煙氣脫硫脫硝處理的相同工藝。
"Gas project" refers to the desulfurizer preparation, supply and process water system in the desulfurization and denitrification section of Chongqing Iron and Steel's new power plant, which adopts the same process as coke oven flue gas desulfurization and denitrification.
良好設計和制造的漿液制備系統作為旋轉噴霧工藝的核心設備，是旋轉霧化器穩定運行和其使用壽命的重要保障。
The well designed and fabricated slurry preparation system, as the core equipment of the rotary spray process, is an important guarantee for the stable operation and service life of the rotary atomizer.
其中“焦?fàn)t項目”的焦?fàn)t煙氣經過余熱鍋爐降溫后，至SDA脫硫+布袋除塵+GGH+SCR脫硝，最后由引風機送至原煙囪排放。
The flue gas of "coke oven project" is cooled by waste heat boiler. Then, the flue gas is sent through SDA desulfurization, bag filter, GGH, SCR denitrification, and finally discharged through stack by induced draft fan.
安徽中易環保為重鋼新建1#-6#焦?fàn)t煙道廢氣脫硫脫硝系統二標段項目中（供貨）SDA脫硫系統“噴霧干燥塔煙氣分配器”。
"Gas disperser of spray drying tower" of SDA desulfurization system in the “coke oven project” is supplied by Anhui Zhongyi EP.
該項目采用典型的旋轉噴霧設計，煙氣經渦流式煙氣分配器形成螺旋流體進入SDA反應塔內與高速旋轉霧化后的脫硫劑溶劑發生反應，達到脫除煙氣中的酸性污染物。
The project adopts a typical rotary spray design. The flue gas enters the SDA reaction tower to react with the desulfurizer solvent after high-speed rotary atomization to remove the acid pollutants in the flue gas.
安徽中易環保作為上述二項目的核心裝備的制造提供方，向該項目總包方寶武水務科技有限公司提供了 “脫硫劑制備系統”和“噴霧干燥塔煙氣分布器”，并為該項目提供現場指導安裝和相關技術服務。
As the manufacturer of the core equipment of the above two projects, Anhui Zhongyi EP supplied "Desulfurizer Preparation System" and "Gas Disperser of Spray Drying Tower” to the general contractor, BAOWU Water Technology, of the two projects. On-site instructions and relevant technical services are also provided by Zhongyi EP.
華星東方作為旋轉噴霧干燥工藝的系統集成商，在火電市場特別是垃圾焚燒發電市場擁有200多座工廠400臺套鍋爐尾氣半干法治理的工程經驗和成套供貨調試業績，擁有霧化器的維保工廠，霧化器實驗平臺及多普勒激光分析儀等重要檢驗儀器，并擁有申克動平衡儀等專用維護和檢修設備。
As a system integrator of the rotary spray drying process, Huaxing has engineering, equipment fabrication, and commissioning performances in the thermal power market, especially over 200 plants and 400 sets of flue gas semi-dry treatment for the waste incineration plants. Huaxing also has maintenance plants for atomizers, atomizer experimental platforms, Doppler laser analyzers, Schenck dynamic balance instrument, and other important inspection instruments.
公司總部設立于江蘇無錫蠡園開發區，在無錫胡埭鎮擁有維保中心和核心裝備制造工廠。
Headquartered in Liyuan Devel. Zone, Wuxi, Huaxing has a maintenance center and a core equipment manufacturing plant in Hudai.
其下屬裝備子公司安徽中易環保，在安徽宣城，河南焦作，山東青島，江蘇泰州等地擁有重型裝備工廠，能生產全套噴霧干燥系統的各類設備，如：霧化器煙氣分布器，噴霧干燥反應器，輸灰，電氣自控等完善的配套設備，方便為各工廠500公里覆蓋范圍內的客戶提供就近供貨、監造和快捷的售后服務。
Its subsidiary, Anhui Zhongyi EP, has heavy equipment factories in Xuancheng Anhui, Jiaozuo Henan, Qingdao Shandong, Taizhou Jiangsu, etc., which can produce a full set of spray drying system equipment, such as atomizer flue gas disperser, spray drying reactor, ash conveying, electrical automatic control and other complete supporting equipment to facilitate the local supply, supervision, and fast after-sales service for customers within the 500 km coverage of each factory.
截止目前，公司服務于上海電氣，上海實業，東方電氣，大唐環境，中電投，中節能，深能源等國內一線電力投資集團及其附屬工程公司，為其配套了大量的鋼結構和成套設備或設計代加工服務。
Huaxing has provided tons of steel structures, complete sets of equipment, and design / OEM services for leading electricity investment groups and their affiliated engineering companies such as Shanghai Electric, SIIC, DEC, Datang Environment, State Power Investment, CECEP, Shenzhen Energy.
公司擁有煙氣超凈排放系統整體設計及制造能力，具備各類檢驗設備和專業檢驗人員，擁有完善的裝備制造能力，同時可為各大電力及鋼鐵集團工程公司的霧化器維保，檢驗分析提供完善的裝備服務。
Huaxing has overall design and manufacturing capability of ultra clean emission FGC, various inspection equipment and professional technician. At the same time, Huaxing is able to provide complete equipment services for atomizer maintenance, inspection, and analysis for engineering companies of steel / power plants.
目前公司正持續為各大電力集團及大型鋼鐵集團提供煙氣超凈排放旋轉噴霧核心裝備及工藝計算，同時為各集團及其附屬工程公司提供設備加工制造和調試等服務。華星東方正致力于將其先進的旋轉噴霧工藝和裝備推廣至電廠及鋼廠煙氣超凈排放領域中。
HXET is continuously providing power / steel groups and their affiliated engineering companies with core equipment and process of ultra clean FGC equipment and commissioning services. Huaxing East is committed to extending its advanced rotary spray process and equipment to the field of ultra clean flue gas emission from power plants and steel mills.
